This paper is aimed to an experimental study on the flow patterns formed by heavy crude oil (initial viscosity and density 488 mPa s, $925.5kg/m3$ at $20°C)$ and water inside vertical and horizontal 2.84-cm-i.d. pipes. The oil-water interfacial tension was 29 dyn/cm. Effort is concentrated into flow pattern characterization, which was visually defined. The similarities with gas-liquid flow patterns are explored and the results are expressed in flow maps. In contrast with other studies, the annular flow pattern (“core annular flow”) was observed in both horizontal and vertical test sections. These flow pattern tends to occur in heavy oil-water flows at low water input fractions. Because of the practical importance of core flow in providing an effective means for heavy oil production and transportation, this paper discusses criteria that favor its occurrence in pipes.

1.
Vanegas Prada, J. W., and Bannwart, A. C., 2000, “Modeling of Vertical Core Annular Flows and Application to Heavy Oil Production,” ETCE2000 & OMAE2000 Joint Conference, CD-ROM, February 14–17, New Orleans, LA.
2.
Charles
,
M. E.
,
Govier
,
G. W.
, and
Hodgson
,
G. W.
,
1961
, “
The Horizontal Pipeline Flow of Equal Density Oil-Water Mixtures
,”
Can. J. Chem. Eng.
,
39
(
1
), pp.
27
36
.
3.
Flores, J. G., Chen, X. T., Sarica, C., and Brill, J. P. 1997, “Characterization of Oil-Water Flow Patterns in Vertical and Deviated Wells,” paper SPE 38810, SPE Annual Technical Conference and Exhibition, San Antonio, TX, 5–8 October.
4.
Trallero, J. L., Sarica, C., and Brill, J. P., 1997, “A Study of Oil/Water Flow Patterns in Horizontal Pipes,” SPE Production & Facilities, SPE 36609, August.
5.
Brauner, N., and Moalem Maron, D., 1999, “Classification of Liquid-Liquid Two-Phase Flow Systems and The Prediction of Flow Pattern Maps,” 2nd International Symposium on Two-Phase Flow Modeling and Experimentation–ISTP’99, Vol. 2, pp. 747–754, Pisa, Italy.
6.
Bannwart, A. C., 1999, “The Role of Surface Tension in Core-Annular Flow,” 2nd International Symposium on Two-Phase Flow Modeling and Experimentation–ISTP’99, Vol. 2, pp. 1297–1302, Pisa, Italy.
7.
Bai, R., 1995, “Traveling Waves in a High Viscosity Ratio and Axisymmetric Core Annular Flow,” Ph.D. thesis, University of Minnesota.
8.
Taitel
,
Y.
,
Barnea
,
D.
, and
Dukler
,
A. E.
,
1980
, “
Modeling Flow Pattern Transitions for Steady Upward Gas-Liquid Flow in Vertical Tubes
,”
AIChE J.
,
26
, pp.
345
354
.
9.
Taitel
,
Y.
, and
Dukler
,
A. E.
,
1976
, “
A Model for Predicting Flow Regime Transitions in Horizontal and Near Horizontal Gas-Liquid Flow
,”
AIChE J.
,
22
, pp.
47
55
.
10.
Joseph
,
D. D.
,
Renardy
,
M.
, and
Renardy
,
Y.
,
1984
, “
Instability of the Flow of Two Immiscible Liquids with Different Viscosities in a Pipe
,”
J. Fluid Mech.
,
141
, pp.
309
317
.
11.
Joseph
,
D. D.
,
Bannwart
,
A. C.
, and
Liu
,
Y. J.
,
1996
, “
Stability of Annular Flow and Slugging
,”
Int. J. Multiphase Flow
,
22
, pp.
1247
1254
.
12.
Bannwart
,
A. C.
,
2001
, “
Bubble Analogy and Stabilization of Core-Annular Flow
,”
J. Energy Resour. Technol.
,
123
, pp.
127
132
.
13.
Clift, R., Grace, J. R., and Weber, M. E., 1978, “Bubbles, Drops and Particles,” Academic Press, New York.
14.
Rodriguez, O. M. H., and Bannwart, A. C., 2000, “The Geometry of Interfacial Waves in Vertical Core-Annular Flow,” International Symposium on Multiphase Flow and Transport Phenomena–MFTP-2000, 5–10 November, 2000, Antalya, Turkey.
15.
Oliemans, R. V. A., 1986. “The Lubricating-Film Model for Core-Annular Flow,” Ph.D. thesis, Technische Hogeschool Delft, Delft University Press, The Netherlands.
16.
Vanegas Prada, J. W., 1999, “Experimental Study of The Annular Oil-Water (“Core-Flow”) for Artificial Lift of Heavy Oils” (in Portuguese) M.Sc. thesis, School of Mechanical Engineering, State University of Campinas, Campinas, Brazil.